Exploded views for Suzuki DT90TC, DT100TC (E01) 1990-2000 [DT90_100_E01]
Cylinder head
Crankcase
Crankshaft
Inlet case
Carburetor (DT100, DT90)
Starter valve
Fuel pump (–1995)
Oil pump (–1995)
Water pump
Throttle link
Oil tank
Gasket set (optional)
Clutch
Transmission
Engine holder
Driveshaft housing
Gear case
Starting motor
Magneto (1989)
Magneto
Ignition coil
Relay
Harness
PTT motor (1989–1990) (DT100, DT90)
PTT motor (1990–2000) (DT100, DT90)
Meter (1) (optional)
Meter (2) (optional)
Meter (3) (optional)
Panel switch (optional)
Trim switch (optional)
Clamp bracket
Swivel bracket
Tilt cylinder
PTT manifold
Lower cover
Engine cover (DT100)
Fuel tank 1/2
Fuel tank (plastic)
Fuel tank 2/2
Remote control box
Tie rod
Maintenance materials
Aftermarket parts are made by other manufacturers to fit and work like the original, often at a lower price. Where only one kind exists, it is shown either way.
Water pump
Replace the impeller at the interval in your owner's manual, or sooner if the cooling water stream weakens.
Water pump repair kit
From the diagram: Water pump
Filters
Change the oil filter with every oil change and the fuel filter at the interval in your owner's manual.
Fuel filter
From the diagram: Fuel pump (–1995)
Ignition and cooling
Spark plugs and thermostat according to the service schedule.
Spark plug
From the diagram: Ignition coil
Corrosion protection
Replace an anode once it has worn down to about half its size.
Propellers
Original propellers listed for this engine.
Propeller
From the diagram: Gear case
